2016-12-06



Reaper, ready…

(click to view full)

The MQ-9 Reaper UAV, once called “Predator B,” is somewhat similar to the famous Predator. Until you look at the tail. Or its size. Or its weapons. It’s called “Reaper” for a reason: while it packs the same surveillance gear, it’s much more of a hunter-killer design. Some have called it the first fielded Unmanned Combat Air Vehicle (UCAV).

The Reaper UCAV will play a significant role in the future USAF, even though its capability set makes the MQ-9 considerably more expensive than MQ-1 Predators. Given these high-end capabilities and expenses, one may not have expected the MQ-9 to enjoy better export success than its famous cousin. Nevertheless, that’s what appears to be happening. MQ-9 operators currently include the USA and Britain, who use it in hunter-killer mode, and Italy. Several other countries are expressing interest, and the steady addition of new payloads are expanding the Reaper’s advantage over competitors…

The MQ-9 Reaper, and its Little Brothers



MQ-1 landing –

1 Hellfire fired?

(click to view full)

The MQ-9 Reaper was once called “Predator B,” but it is only loosely based on the famous MQ-1 Predator drone. The Reaper is 36 feet long, with a 66 foot wingspan that can be modified to 88 feet. Its maximum gross takeoff weight is a whopping 10,500 pounds, carrying up to 4,000 pounds of fuel, 850 pounds of internal/ sensor payload, and another 3,000 pounds on its wings. Its 6 pylons can carry heavier reconnaissance payloads, as well as an impressive array of weapons including GPS-guided JDAM family bombs, Paveway laser-guided bombs, Sidewinder missiles for air-air self defense or ground strike use, and other MIL STD 1760 compatible weapons, in addition to the Hellfire anti-armor missiles carried by the Predator. The Reaper becomes the equivalent of a close air support fighter with less situational awareness, lower speed, and less survivability if seen – but much, much longer on-station time.

The MQ-1A/B Predator. This UAV is flown by the USAF and Italy. It’s 27 feet long, with a 55 foot wingspan. Maximum gross takeoff weight is 2,3000 pounds, and it can carry 625 pounds of fuel, 450 pounds of internal payload (sensors), and another 300 pounds on its wings for up to 2 AGM-114 Hellfire anti-armor missiles or equivalent loads. Its service ceiling is 25,000 feet, which can keep it well above the 10,000-15,000 ceiling above which most guns are ineffective. The piston engine is a Rotax 914 turbo that runs on aviation fuel, and pushes the Predator at a slow speed of 120 KTAS. It’s controlled by UHF/VHF radio signals.

US Army MQ-1C ER/MP. The Gray Eagle looks a lot like the Predator but is a little bit bigger, can carry more weapons, and has an engine that can run on the same “heavy fuel” that fills up the Army’s land vehicles. It’s 28 feet long, with a 56 foot wingspan and a service ceiling of 29,000 feet. Maximum gross takeoff weight is 3,200 pounds, carrying up to 600 pounds of fuel, 575 pounds of internal payload (sensors, plus a communications relay), and another 500 pounds on its wings. This doubles weapon capacity, to 4 AGM-114 Hellfire anti-armor missiles or equivalent loads.The piston engine is a Thielert 135hp that runs on heavy fuel or higher-grade aviation fuel, and gives it a slightly faster speed of 135 KTAS. The Improved Gray Eagle substitutes a higher-power Lycoming DL-120 engine, while adding fuel and payload.

The USAF also had an MQ-1B Block X/ YMQ-1C project to develop a Predator system that would run on heavy fuel and carry up to 4 Hellfires. They canceled it, and their Predator buys in general, in favor of the MQ-9 Reaper.



MQ-1 vs. MQ-9

(click to view full)

The MQ-9 Reaper. This UAV is far more of a fighter substitute or close-air support complement than other UAVs. Larger than its companion MQ-1 UAVs, its reinforced wings give it far greater weapons carrying capacity of 3,000 pounds. Since most manned jet fighters aren’t carrying that many precision weapons for close support missions over Iraq and Afghanistan, that limit lets the MQ-9 fulfill close-air support roles in most low-intensity conflicts.

Its service ceiling is reportedly 50,000 feet unless it’s fully loaded, which can make a lurking Reaper very difficult to find from the ground. That wouldn’t have been useful to UAVs like the Predator, given the Hellfire missile’s range. On the other hand, the ability to drop GPS and laser-guided bombs makes precision high altitude Reaper strikes perfectly plausible. As one might expect, the MQ-9 Reaper’s default sensor package is more capable than the MQ-1 family’s; it includes General Atomics’ AN/APY-8 Lynx I ground-looking radar, and Raytheon’s MTS-B (AN/AAS-52) surveillance and targeting turret.

The engine is a Honeywell TPE 331-10T, which pushes it along at a rather speedier clip of 240 knots. Not exactly an F-16, or even an A-10, but the Reaper’s extra speed does get it to the problem area faster than a Predator could. A total fatigue limit of 20,000 safe fight hours is about double that of a life-extended F-16, and around 20% higher than an EMB-314/ A-29 Super Tucano counter-insurgency turboprop. The flip side is that UAVs have about twice as many accidents as manned fighters.

Horsham AS brief

Reaper ER. This upgrade adds stronger landing gear, a pair of “wet” hardpoints that can handle a pair of fuel tanks, and a stretched 88′ wingspan that includes the ability to carry fuel in the wings. The standard Reaper is configured for 30 hours in surveillance mode, and roughly 23 hours if armed with Hellfire missiles. General Atomics believes the ER model will raise that to 42 hours for ISR and 35 hours with the Hellfire.

Block 5. The latest MQ-9 version is the Block 1+, soon to be known as Block 5. Improvements focus on 3 areas: power capacity, payload capacity, and communications capacity. Power is improved via a new high-capacity starter generator, and an upgraded electrical system whose new backup generator can support all flight critical functions with a triple redundancy. Payload is improved using new trailing arm heavyweight landing gear (TA-MLG), and a weapons kit upgrade from BRU-15 [PDF] bomb release units to ITT Exelis’ BRU-71/A [PDF]. Finally, communications upgrades include encrypted datalinks, bandwodth improvements, upgraded software to allow the 2-person aircrew to operate all onboard systems, and dual ARC-210 VHF/UHF radios with wingtip antennas that allow simultaneous communications between multiple air-to-air and air-to-ground parties.

SOCOM. US Special Operations Command (SOCOM) flies the MQ-9 Reaper and MQ-1 Predators. Both are referred to as Medium Altitude Long Endurance Tactical (MALET) platforms, and the 160th SOAR added the MQ-1C Gray Eagle in November 2013. If SOCOM has to bring the MALET down to hammer a target, they fly in enhanced variants with improved video transmission, infrared modifications, signals intelligence payloads, and “delivery of low collateral damage weapons.” The latter presumably includes precision mini-missile options like Raytheon’s Griffin, and precision glide bombs like Northrop Grumman’s GBU-44 Viper Strike and Lockheed Martin’s Scorpion, all of which allow a single Hellfire rail or weapon station to carry multiple weapons. SOCOM does want the Reaper to be more transportable, though, for quick delivery and use in theater.

Other. General Atomics’ Mariner/ Guardian maritime surveillance variant and FAA-certified high-altitude Altair research UAV are both derived from the MQ-9 Reaper. So, too, is NASA’s Ikhana.

Program Highlights

A basic MQ-9 Reaper system consists of 4 UAVs, each with a Raytheon MTS-B day/night surveillance and targeting turret, General Atomics AN/APY-8 Lynx ground-looking SAR/GMTI radar, and satellite communications equipment; Weapon kits with integrated hardpoints for certified weapons; 1 Ground Control System; and Ground Data Terminals.

Operational squadrons will also have appropriate support equipment, simulator and training devices, and Readiness Spares Packages (RSP) on hand. A lot of support is still handled by contractors, but some is being moved inside the military.

Excel

download

The average flyaway cost of an MQ-9 is between $17-21 million, based on FY 2015 budget documents. Note that flyaway cost subtotals also include shares of Ground Control Stations (GCS), Ground Data Terminals (GDTs), and Predator Primary Satellite Links (PPSLs), which means that buying different numbers of ancillary systems or UAVs changes the cost number from year to year.

Export buyers will incur higher costs, as the few UAVs they buy need the entire set of back-end infrastructure and support systems. Co-location with the USAF or Britain in a satellite-linked operations center can help defray the biggest expenses, but costs will still be far higher than they would be for a USAF purchase.

American budget totals reflect the number of individual UAVs purchased, though each year is also buying the other equipment needed to make the Reapers work, and making long lead-time buys for the following year. Note that both RDT&E funding and procurement funding beyond FY 2015 reflect the USAF only, and don’t include the minor contributions of US SOCOM.

A complete timeline of the MQ-9 program, including export sales and requests, and planned milestones:

Competitors & Prospects

USAF on UAV futures

The MQ-9 has few competitors at the moment. Other UCAVs like the US Navy’s X-47 UCAS-D, the European nEUROn project, and Britain’s Taranis all focused on the stealthy fighter replacement role, and conventional UAVs optimized for surveillance rather than strike, Serious competition would involve existing UAVs that begin integrating and proving a variety of weapon sets, and have the capacity to carry a substantial payload. The challenge is that many of those UAVs will hit limits to payload carriage or endurance before they can match the Reaper, or run afoul of the 300 mile range/ 500 pound ordnance limit embedded in the Missile Technology Control Regime treaty.

The BAE Mantis/ Telemos UAV, whose twin pusher-propeller design and T-tail make it look like the unmanned offspring of an A-10 “Warthog” and Argentina’s IA 58 Pucara counter-insurgency aircraft, was well positioned to compete. Instead, it was sidelined by lack of funding and commitment from Britain and France. Israel has UAVs in a similar size class (Heron-TP, Hermes 900, Dominator), but they don’t routinely carry weapons, and heaven’t been exported as armed UAVs. Italy and the UAE are building Piaggio’s fast Hammerhead P.1HH, but the MCTR cripples its payload, and plans to arm the UAV remain distant. The UAE touts their Yabhon United 40 Block 5, but it needs to be inducted and proven in operational service. China has begun to export its Wing Loong armed UAV, but its peer comparison is the MQ-1 Predator.

That’s the good news for General Atomics. The bad news is that is that MQ-9 export approval beyond NATO and similarly close allies seems unlikely. MQ-9s are currently in service with the USAF, Britain (10), France (2), and Italy (4). The Netherlands has committed to buy 4, but hasn’t placed a contract yet. Poland is also said to be considering a purchase, and Germany was a strong export candidate before its current government backed off buying any drones at all. Note that even within this group, Britain has been the only country allowed to arm their Reapers.

Future Planning & Developments

MQ-9 Block 5

(click to view full)

As of March 2013, the USAF intends to fulfill the MQ-9 Increment One CPD requirements with a final UAS configuration consisting of the MQ-9 Block 5 UAV with OFP 904.6, and the Block 30 GCS. The program will be reducing or deferring 12 required block 5 capabilities related to aircraft endurance, radar performance, and reliability, and other areas. The UAV’s core OFP flight software has been a development issue, and DOT&E expects further delays, along with added risks because cyber-vulnerabilities haven’t been heavily tested.

AFOTEC hoped to conduct formal operational testing of the final MQ-9 Increment One UAS in late 2014, but the addition of manufacturing issues has pushed things back to early 2016.

“Increment II” upgrades beyond the MQ-9 Block 5 were slated to include GBU-39 Small Diameter Bomb integration, Automatic take-off and landing, Deicing, and National Airspace certification for flights in American civil airspace. At present, those upgrades languish in an unfunded limbo.

Contracts & Key Events, 2005 SDD – Present

MQ-9, Kandahar

(click to view full)

Some support contracts are common to the MQ-1 Predator and MQ-9 Reaper fleet. They are not covered here. Britain’s MQ-9 Reaper program has its own DID Spotlight article, but its items are reproduced here as well.

Unless otherwise indicated, all contracts are managed by Wright-Patterson AFB, OH, where the 658th AESS/PK is the Predator Contracting Group. General Atomics Aeronautical Systems, Inc. of Poway, CA (near San Diego, north of MCAS Miramar) is the contractor. Note that, for whatever reason, many USAF orders don’t seem to be announced through standard channels. See budgets, above, for a clearer sense of the numbers involved.

FY 2014 – 2017

Afghan Pre-Flight

(click to view full)

December 6/16: Contracts have been signed between General Atomics and the UK government to develop new UAVs. The company will equip existing drone technology into new remotely piloted aircraft for the RAF, in a deal worth $127 million. 20 Protector UAVs will be developed under the program and will replace the current fleet of 10 MQ-9 Reapers.

October 28/16: It’s been reported that the US military is using bases in Tunisia to conduct surveillance drone operations against Islamic State militants in Libya with unarmed MQ-9 Reaper UAVs. However Tunisian sources have denied that the drones have been in Libyan airspace and instead are being used for training Tunisian forces and protecting the country’s borders. Following attacks by jihadists in a popular vacation destination in 2015, Washington has given more than $250 million in security assistance to Tunisia while the UK has provided personnel to train Tunisian forces.

September 30/16: Building is underway by the US military of a $100 million facility for the use of MQ-9 Reaper operations in the region. The news comes less than a year after the announcement was made that Reaper and Predator bases in Ethiopia and Djibouti would be closed. MQ-9s operated from East African bases are used primarily for missions against Islamic insurgents such as al-Shabaab in Somalia and AQAP in Yemen.

August 24/16: General Atomics has been contracted by the Missile Defense Agency (MDA) to develop a laser tracking system for the MQ-9 Reaper UAV. Valued at $9.6 million, the contract will set the company to design, build and test in the lab key laser subsystems to demonstrate precision tracking. Furthermore, the company will develop and demonstrate an MQ-9 flight representative laser system with the beam train optics required to upgrade a multi-spectral targeting system for use as an active tracking sensor.

August 19/16: General Atomics is to provide 30 MQ-9 Reaper UAVs to the USAF. The $370.9 million contract will be completed by May 31, 2019.

August 8/16: MQ-1 Predator and MQ-9 Reaper pilots are to undergo a fifteen-day course in electric warfare missions. The USAF program will see pilots gain training so that they can continue to operate their UAV when under electronic attack such as jamming of their satellite uplinks. Once completed, they will be known as Electronic Combat Officers.

June 27/16: India has issued a Letter of Request (LoR) to the US government over the potential purchase of 22 General Atomics Guardians, a maritime patrol variant of the MQ-9 Predator B. A letter of acceptance from the US will follow later in the year which will trigger the commencement of price negotiations over the UAVs with a final contract to be signed sometime in 2017-18. It is unclear, however, whether the Indian Navy will acquire the non-weaponized Guardian variant – featuring intelligence, surveillance, and reconnaissance (ISR) capabilities – the weaponized one, or both.

June 3/16: MQ-9 UAVs operated by the Italian Air Force are to be fitted with General Atomics integrated Rafael RecceLite reconnaissance pod. Flight testing will be carried out in early 2017 at Amendola Air Base, Italy. The company believes that the adoption of the system “could lead to similar efforts with other NATO customers that operate MQ-9.”

May 5/16: An upgrade to automate takeoff and landing of MQ-9 Reaper UAVs is being pursued by the USAF, making training Reaper pilots easier and allowing access to more runways. A similar upgrade already exists on US Army MQ-1C Grey Eagles. According to General Atomics’ senior director of strategic development, Chris Pehrson, the air force tried last year to shift money from other accounts to begin implementing the automatic takeoff and landing system, but the request was denied by Congress.

April 28/16: After numerous delays in its maiden flight which occurred last week amid much excitement from manufacturer Mitsubishi Heavy Industries (MHI), the X-2 stealth demonstrator will have a year long test campaign involving around 50 flights. With the maiden flight described as “ordinary” by Hirofumi Doi, manager of Japan’s Future Fighter Program at the defence ministry’s Acquisition, Technology & Logistics Agency (ATLA), future testing will help ATLA gather data on advanced fighter technologies such as stealth, thrust vectoring, data links, and other areas. Depending on this data, flight testing of the X-2 could easily be extended, leading the way for a potentially busy period for the demonstrator.

March 22/16: The USAF and Honeywell are investigating a still-undetermined problem with the starter-generator on the MQ-9 Reaper Block 1 version’s Honeywell turboprop engine. Seventeen MQ-9 crashes have been avoided since last April, however, thanks to a backup electrical system that has been installed as a safeguard, which allows for the aircraft to fly for another ten hours. Since the UAV’s first flight, the USAF have lost dozens during missions, at a cost of $20-25 million per aircraft. This has intensified in 2015, as the steeping up of anti-terrorism operations in Afghanistan, Iraq, Syria, and Africa saw 10 MQ-9 and 10 MQ-1 crashes in that last year alone.

February 19/16: General Atomics has received a contract to provide four unarmed MQ-9 Reaper UAVs and two Block 30 ground control stations to Spain. While Madrid may seek to arm the UAVs in future, it requires authorization from the US government before it can do so. However, this may not be too much of an issue, as both the UK and Italy have already been granted permission to arm their fleets with precision guided missiles such as the AGM-114 Hellfire. While the initial foreign sales notice posted by the US in October cites the cost of the hardware at $80 million, the total cost of procurement, training and logistical support could see that cost more in the region of $243 million.

January 21/16: A second MQ-9 Reaper UAV system will be delivered to France by October 2017 after the US DoD announced contracts on Tuesday. Work and delivery of the system is set to cost $47.7 million and will be carried out by General Atomics Aeronautical Systems. The awarding of the contract follows the December order of a third batch of Reaper systems by France set for delivery in 2019. France has been operating the UAVs on missions on the African continent, primarily in the Sahel-Saharan region. The MQ-9s will most likely continue to be operated until a pan-European UAV development project is completed which will see a drone developed jointly by France, Germany and Italy.

December 28/15: After two decades, General Atomics will cease production of the RQ-1 Predator UAV after the final two were delivered to the Italian Air Force. While not officially confirmed, it is believed that the Italians operate nine RQ-1s for intelligence gathering. Furthermore, they have procured six of the RQ-1’s successor, the MQ-9 Reaper which have recently been approved by the US government to carry weapons. The aircraft are primarily utilized by the Italians over the Mediterranean Sea and in support of NATO operations.

November 6/15: The State Department has approved a Foreign Military Sale contract to weaponize the Italian Air Force’s fleet of MQ-9 Reaper UAVs. The DSCA request included AGM-114R2 Hellfire II missiles, JDAM guided bombs and launchers, with the possible deal estimated to value $129.6 million. General Atomics will be the prime contractor for the potential sale, the US government having relaxed export restrictions in February, with the weaponization of the Italian Reapers representing the second international customer to operate armed MQ-9s. The Royal Air Force is the sole weaponized operator outside of the US.

November 4/15: Spain’s cabinet has approved a proposed acquisition of four MQ-9 Reaper Block 5 UAVs from the US, following State Department approval of a DSCA request by the country’s Defense Ministry in October. The $177 million procurement saw the General Atomics design – favored by the Spanish Air Force – beat off competition from Israel Aerospace Industries’ Heron TP. The contract’s value will be spread over a multi-year contract until 2020, with Spanish firm SENER acting as General Atomics’ partner. Elsewhere in Europe, the Netherlands also requested four of the same aircraft in February, with the United Kingdom operating armed Reapers.

October 30/15: The deputy head of the Air Force ISR wants to counteract a shortfall in MQ-1 Predator and MQ-9 Reaper operators by compressing the current two-person arrangement into a single role. The conversion would require changes to the system’s ground station, with Air Force officials keen to maximise manpower efficiency in the face of high drop-out rates for drone pilots.

October 8/15: The State Department has given the green light to Spain acquiring four MQ-9 Reaper Block 5 UAVs, through a potential acquisition valued at $243 million along with auxiliary equipment and services. The Spanish Defence Ministry set aside money in its 2016 budget for the four UAVs, which it reportedly opted to sole-source from manufacturer General Atomics. The Reapers will be used exclusively for ISR, with the United Kingdom the only nation currently operating armed Reapers outside of the US, with the Netherlands also requesting four MQ-9s in February. Spain’s proposed sale will now be referred to Congress for approval.

September 28/15: General Atomics has unveiled a new capability for its MQ-9B Guardian maritime UAV, presenting a sonobuoy capability along with other modifications to the Royal Navy in a bid to market the Guardian as an unmanned maritime patrol aircraft to supplement the likely procurement of a manned maritime patrol aircraft. Calls from industry for the UK’s Defence Ministry to run a competition for its future maritime patrol aircraft are growing louder, with Northrop Grumman thought to be considering an offer of their RQ-4C Triton as another unmanned option in addition to the Guardian.

August 7/15: Spain has decided to buy four unarmed MQ-9 Reaper UAVs, along with two ground stations. The fifth European country to purchase the Reaper, the Spanish defense ministry has allocated $186.9 million for the acquisition. The United Kingdom, France and Italy operate the Reaper, with the Netherlands requesting four in February.

August 5/15: The Air Force’s Scientific Advisory Board (SAB) has recommended adding new sensors, weapons and countermeasures to MQ-9 Reaper and RQ-4 Global Hawk UAVs to increase survivability and lethality in contested airspace. The SAB is also pushing for Manned-Unmanned Teaming, something already baked into the latest iteration of the AH-64E Block III Apache, with tests in June demonstrating the helicopter operating alongside a MQ-1C Gray Eagle, with the UAV assisting in target-painting and surveillance. A full report on the topic – ‘Enhanced Utility of Unmanned Air Vehicles In Contested and Denied Environments’ – will be published in December.

June 5/15: The UK and France are exploring the possibility of collaborating for Reaper UAV training, logistics and support services. The British operate ten of the aircraft, with these all deployed on operations over Iraq, with France taking delivery of a third Reaper at the end of May, with twelve set to be delivered by 2019.

May 21/15: General Atomics was awarded a production contract for eight additional MQ-9 Reaper Block 5 UAVs on Wednesday, with this $72.1 million contract following a similar $279.1 million order for 24 of the aircraft last month.

July 2/14: Germany. The whole subject of UAVs remains very contentious along left-right lines (q.v. Nov 14/13), as a long Defence Committee hearing on June 30/14 demonstrated once again. But German Defence Minister Dr. Ursula von der Leyen [CDU] has now stated her support for buying UAVs that can carry weapons, on the condition that the German Bundestag would vote to send them on any foreign missions, and decide whether they should be armed.

That would seemingly favor the MQ-9 in the short term, but she stated her satisfaction with the current leasing program for Heron-1 UAVs, which can be continued without sparking a divisive armed UAV debate in the Bundestag. Over the longer term, she also spoke in favour of developing “a European armed drone.” The NSA remains the political gift that keeps on giving to non-American defense sector competitors:

“Once again, the NSA affair has made it clear to me what it means to lie dormant through 10 to 15 years of technological development and suddenly face the bitter reality of how dependent one is on others…. Europe needs the capabilities of a reconnaissance drone so it is not permanently dependent on others.”

The challenge is that European partners want a UAV that can carry weapons, so Germany probably needs to accept that in order to find partners. Time will tell. Source: Euractiv, “German defence minister backs ‘European armed drone'”.

June 26/14: Upgrades. General Atomics – Aeronautical Systems, Inc. in Poway, CA receives a $15.3 million firm-fixed-price sole-source contract for the MQ-9 Fuel Bladder Retrofit Kits, Time Compliance Technical Orders (TCTO) and initial spares. The certified O-level TCTOs enable the removal of existing Aero Tech Labs fuel bladders, and enable the installation of the new fuel bladders on MQ-9 Reaper Block 1 aircraft. GA-ASI will also update existing technical orders and manuals, and deliver initial retrofit spares. All funds are committed immediately, using FY 2012 & 2013 USAF aircraft budgets.

Work will be performed in Poway, CA, and is expected to be complete by March 6/17. USAF Life Cycle Management Center’s, Medium Altitude Unmanned Aircraft Systems group at Wright-Patterson AFB, OH manages the contract (FA8620-10-G-3038, DO 0071).

May 9/14: Australia. Air Marshal Geoff Brown tells Fairfax Media that he’d like to see Australia buy some MQ-9s. Australia has trialed MQ-9s in a maritime border patrol role (q.v. May-September 2006). Their military intends to move ahead with the jet-powered MQ-4C Global Hawk derivative that won the US Navy BAMS competition, but an MQ-9 fleet bought to support the Army would likely find itself on call to support Coast Guard duties as well. That could be done with standard equipment, as Italy has done (q.v. Jan 15/14), or via additional buys to obtain SeaVue radars like the MQ-9 Guardians operated by US Customs (q.v. Dec 7/09). Brown:

“I’m a great fan of capabilities that have a very multi-role aspect to them, and I think Predator-Reaper does have that… I think the combination of a good ISR platform that’s weaponized is a pretty legitimate weapon system for Australia…. I’d love to have [MQ-4C] Triton tomorrow… I’d certainly like to have Predator-Reaper capability as well, and I’d like to bring [our rented fleet of IAI’s] Heron back so we build on those skills that we’ve got.”

He’s thinking in terms of the next 5 years, and the place to set that in motion would be the coming Force Structure Review. Sources: Sydney Morning Herald, “Air Force wants to buy deadly Reaper drones”.

April 17/14: SAR. The Pentagon releases its Dec 31/13 Selected Acquisitions Report. For the MQ-9:

“Program costs decreased $1,451.8 million (-10.9%) from $13,318.2 million to $11,866.4 million, due primarily to a quantity decrease of 58 aircraft from 401 to 343 (-$962.1 million), associated schedule, engineering, and estimating allocations (+$66.9 million), and areduction of initial spares and support equipment related to the decrease in quantity (-$432.9 million). There were additional decreases for the removal of the Airborne Signals Intelligence payload 2C (ASIP 2C) requirement (-$280.1 million) and sequestration reductions (-$142.5 million). These decreases were partially offset by increases for a warfighter requirement for extended range retrofits and communications requirements (+$138.9 million) and the addition of production line shut down costs that were not previously estimated (+$132.7 million).”

Program cuts

March 31/14: GAO Report. The US GAO tables its “Assessments of Selected Weapon Programs“. Which is actually a review for 2013, plus time to compile and publish. The MQ-9 Block 5’s manufacturing issues include “delinquencies in completing technical data, software delays, and fuel tank issues”; the latter were severe enough that they required production line changes and fleet retrofits. As a result, deliveries were slowed, operational testing had to move back from October 2014 to January 2016, and Block 5 software won’t be fully fielded until March 2016. Meanwhile,

“As of December 2013, 21 Block 1 aircraft have been produced, but are still awaiting the necessary software capability upgrades before they can be delivered. Until these software upgrades are complete, aircraft are only being delivered based on urgent needs. According to program officials, the program has developed an aircraft delivery recovery plan that should allow deliveries to be back on track by April 2014.”

Since more than half of the planned fleet will have been manufactured before a “Full Rate Production Decision” is made, the Pentagon has decided to have an “in-process review” in February 2016 instead.

March 26/14: Weapons. An MQ-9 successfully finishes December 2013 – January 2014 tests at US Naval Air Weapons Station China Lake, CA, firing MBDA’s dual-mode radar/laser Brimstone missile against a variety of targets. The Brimstone is similar to the Reaper’s regular laser-guided AGM-114 Hellfire, with a slightly longer range, a fire-and-forget radar seeker, a “man in the loop” feature, and the ability to deploy on fast jets. Consolidating on the Brimstone would let the RAF use a single weapon type for short-range light strike.

The test was a cooperative effort between Britain and the United States (q,v, May 3/13), and all of the RAF’s primary and secondary trial objectives were met. Brimstone isn’t formally integrated onto the MQ-9, but it looks as if that’s about to change. Sources: MBDA, “MBDA’s Brimstone Demonstrates its Precision Low Collateral Capability from Reaper”.

March 4-11/14: FY15 Budget. The US military slowly files its budget documents, detailing planned spending from FY 2014 – 2019. The FY 2015 request supports the procurement of 12 MQ-9 UAVs and 12 fixed ground control stations, while funding MQ-9 Extended Range fleet modifications. Deliveries out to 2019 are being cut, but the budget isn’t changing that much because of required investments in spare parts, support infrastructure, and technical data rights.

There are currently 143 MQ-9 aircraft in USAF inventory, with an estimated designed service life of 20,000 hours each. For comparison purpose, that’s about double the total lifespan of an F-16 with life-extension refits, and slightly longer than a manned Super Tucano turboprop’s ~16-18,000 hours.

Near-term upgrades include new Linux processors, high definition monitors, and ergonomic improvements. Future planned upgrades include integrating improved human-machine interfaces, open systems architecture, improved crew habitability, and multiple aircraft control. Future GCS configurations will leverage the Unmanned Aerospace System (UAS) Command and Control (C2) Initiative (UCI) government-owned open system standard to enable improved capabilities for situational awareness and multi-mission management monitoring and oversight.

Feb 24/14: Budgets. Chuck Hagel’s FY 2015 pre-budget briefing explains that cutbacks are on the way for the drone fleet, but perhaps not the Reapers:

“The Air Force will slow the growth in its arsenal of armed unmanned systems that, while effective against insurgents and terrorists, cannot operate in the face of enemy aircraft and modern air defenses. Instead of increasing to a force of 65 around-the-clock combat air patrols of Predator and Reaper aircraft, the Air Force will grow to 55, still a significant increase. Given the continued drawdown in Afghanistan, this level of coverage will be sufficient to meet our requirements, and we would still be able to surge to an unprecedented 71 combat air patrols under this plan. DoD will continue buying the more capable Reapers until we have an all-Reaper fleet.

If sequestration-level cuts are re-imposed in 2016 and beyond, however, the Air Force would need to make far more significant cuts to force structure and modernization. The Air Force would have to retire 80 more aircraft, including the entire KC-10 tanker fleet and the Global Hawk Block 40 fleet, as well as slow down purchases of the Joint Strike Fighter – resulting in 24 fewer F-35s purchased through Fiscal Year 2019 – and sustain ten fewer Predator and Reaper 24-hour combat air patrols [DID: down to 45]. The Air Force would also have to take deep cuts to flying hours, which would prevent a return to adequate readiness levels.”

Sources: US DoD, “Remarks By Secretary Of Defense Chuck Hagel FY 2015 Budget Preview Pentagon Press Briefing Room Monday, February 24, 2014”.

Feb 5/14: Bandwidth innovation. The USAF touts changes they’ve made to the MQ-9 Reaper, allowing it to relay data through inclined orbit satellites that have become slightly unstable. The satellites’ wobble cuts their leasing costs sharply, so UAVs can cut operating costs by integrating updated satellite location data with software to point their receivers, and having procedures to manage the associated situations. The USAF has successfully tested exactly this kind of system on the MQ-1 and MQ-9 UAVs.

The Jan 28/14 DOT&E report gave the MQ-9 program both barrels for what it saw as lack of organization, and a development culture that pursued off-record efforts at the expense of their planned capabilities. Announcements like this one, and the Feb 5/14 AFSOC report, remind us that less-planned but potentially significant enhancements can add up to important steps forward. Read “I.O. Satellites for UAVs? USAF Reaping Savings” for full coverage.

Feb 5/14: 38 ER conversions. A maximum $117.3 million unfinalized contract will finance conversions to create 38 MQ-9 Extended Range UAVs, with larger wings and more fuel.

$41.5 million committed immediately, using a combination of FY 2013-2014 RDT&E budgets, and the FY 2014 aircraft budget. Work will be performed in Poway, CA, and is expected to be complete by July 7/16. USAF Lifecycle Management Center/WIIK’s Medium Altitude Unmanned Aircraft Systems group at Wright-Patterson AFB, OH manages the contract (FA8620-10-G-3038, #0118).

MQ-9 ER conversions begin

Feb 5/14: AFSOC Support. A $166 million delivery order for “Lead-off Hitter AFSOC MQ-9 Software Line,” which will provide MQ-9 software engineering support for the AFSOC fleet of MQ-9 unmanned aerial systems. In an interesting note about some of the changes underway, the FY 2013 DOT&E report mentioned that:

“AFSOC demonstrated the successful transmission of encrypted, high-definition full motion video from the RPA to remote video terminal-equipped ground units in support of urgent AFSOC capabilities needs. AFOTEC will conduct formal evaluation of full motion video transmission during FOT&E of the MQ-9 Increment One system.”

Work will be performed in Poway, Calif., and is expected to be completed by Feb. 6, 2015. Fiscal 2013 research and development funds in the amount of $2,063,006 are being obligated at time of award. Air Force Life Cycle Management Center/WIIK, Medium Altitude Unmanned Aircraft Systems, Wright-Patterson Air Force Base, Ohio, is the contracting activity (FA8620-10-G-3038, DO 0114).

Jan 28/14: DOT&E Testing Report. The Pentagon releases the FY 2013 Annual Report from its Office of the Director, Operational Test & Evaluation (DOT&E). The MQ-9 is included, and the report paints the program as a mess, getting UAVs out the door but tripping over itself elsewhere thanks to the lack of an Integrated Master Schedule, inability to prioritize or meet timelines, and only limited Information Assurance cyber-testing.

The result of these failings, in conjunction with “competing schedule priorities for non-program of record capabilities,” is that the program formally acknowledged an Acquisition Program Baseline (APB) breach in May 2013 and said they couldn’t meet the program of record schedule. The Increment 1/ Block 5 system can’t undergo Full OT&E in FY 2014 as planned, and integration of the GBU-38 JDAM was postponed. Indeed:

“Development, operational testing, and fielding of Increment One program of record capabilities will likely experience continued delays until the program is able to better prioritize and control maturation of these capabilities in accordance with a predictable schedule. Ongoing schedule challenges, combined with RPA production emphasis, increase the likelihood that the MQ-9 UAS will complete the delivery of all planned MQ-9 RPAs under low-rate initial production. FOT&E of the Increment One UAS configuration, originally planned for 2013, will likely be delayed several years beyond FY14.”

Jan 22/14: EW. General Atomics and Northrop Grumman conduct the 2nd USMC demonstration of MQ-9s as electronic warfare platforms (q.v. Aug 13/13), using NGC’s Pandora low-power, wideband electronic warfare pod. They tested Pandora’s compatibility with the Reaper’s avionics and command and control architecture, including control of the Pandora pod’s operations, and tested the entire system’s integration into a Marine Command and Control (C2) network.

A Cyber/Electronic Warfare Coordination Cell (CEWCC) located at MCAS Yuma ran the pod and UAV, which supported a large aircraft strike package that included EA-6B Prowler jamming aircraft. General Atomics sees this as an important way to broaden the Reaper’s usefulness, in order to keep it from budget cuts (q.v. Jan 2/14). Sources: GA-ASI, “GA-ASI and Northrop Grumman Showcase Additional Unmanned Electronic Attack Capabilities in Second USMC Exercise”.

Jan 15/14: UAV SAR. General Atomics touts the use of its MQ-1 and MQ-9 UAVs in search and rescue scenarios, which will become much easier once civil airspace rules are changed to provide clear requirements for UAVs.

MQ-9 UAVs were used in New Mexico to find missing kayyakers in April 2012, and MQ-1s and MQ-9s were both used in October 2013 to find a missing German mountain biker who was stranded and injured in the Lincoln National Forest. Interestingly, their main role was to search less-likely areas, ensuring that they were covered while allowing humans to search the most likely areas.

The Italian jobs were a bit different, because they were conducted under Operation Mare Nostrum (“our ocean,” also colloquial Roman for the Mediterranean), which aims to find and rescue migrants who are trying to cross the sea in makeshift boats from North Africa. They use radar more extensively, and the Italian MQ-9s’ AN/APY-8 Lynx Block 30 multi-mode radars will soon add software to give them a new Maritime Wide Area Search (MWAS) mode. Sources: GA-ASI, “Predator-Series Aircraft Pivotal to Search and Rescue Missions”.

Jan 2/14: Budgets. Military.com quotes Pentagon director of unmanned warfare and ISR Dyke Weatherington, who says of the new UAV Roadmap that the 24% reduction in UAV spending of from 2012-2013, and 30% cut from 2013-2014, is a trend that will continue. The shift to the Pacific is likely to hurt UAVs below the top end, but:

“This roadmap is two years since the last one. We knew budgets would be declining. I don’t think two years ago we understood how significant the down slope was going to be so this road map much more clearly addresses the fiscal challenges…. We can generally say that from 2014 to 2015 the budget… will be reduced”…. there was about a 24-percent reduction from 2012 to 2013 and a 30-percent reduction from 2013 to 2014…. the Pentagon’s shift to the Pacific and overall Defense Strategy articulates a need to be prepared for more technologically advanced potential adversaries…. “EW is one of those areas where we are going to see opportunities for unmanned systems, likely in tandem with manned systems…”

In this environment, the program to add MALD-J loitering jamming decoys is promising for the MQ-9, but further budget cuts are not. Sources: DoD Buzz, “Pentagon Plans for Cuts to Drone Budgets”.

Jan 1/14: France. Defense World reports that French MQ-9s arrived “in the Sahel Region” on this day, for operations over Mali. Defense World, “France Receive First MQ-9 Reaper Drone”.

Dec 31/13: UK Support. A sole-source, unfinalized $31.9 million cost-plus-fixed-fee and firm-fixed-price option for Phase 1 & 2 contractor logistics support: urgent repairs and services, logistics support, field service representative support, contractor inventory control point and spares management, depot repair, flight operations support and field maintenance.

Work will be performed in Poway, CA, and is expected to be complete by March 31/15. The USAF acts as Britain’s agent (FA8620-10-G-3038, 0080, 09).

Dec 24/13: Support. A $362.2 million cost-plus-fixed-fee sole-source contract for MQ-1 Predator and MQ-9 Reaper contractor support, including program management, logistics support, configuration management, technical manual and software maintenance, contractor field service representative support, inventory control point management, flight operations support, depot repair, and depot field maintenance.

$90 million in USAF O&M funds are committed immediately. Work will be performed at Poway, CA, and is expected to be complete by Dec 31/14. The USAF Life Cycle Management Center/WIKBA at Robins AFB, GA manages the contract (FA8528-14-C-0001).

Dec 19/13: France. The DGA procurement agency receives its 1st Reaper UAV, which is being readied for deployment to Mali along with a 2nd UAV, associated ground systems, etc. The DGA praises the USA’s help in getting personnel trained, helping with communications planning, etc. A record of six months from order to delivery is impressive, and demands nothing less.

French delivery

Nov 21/13: Dutch OK. The Dutch MvD delivers a report to the legislature, announcing the results of their MALE UAV program study phase, which began in 2012. Their requirements included 24 hour endurance, and payload options that included the standard surveillance and targeting turret and SAR/GMTI ground scanning radar, plus a wide-area ground-scanning radar and a SIGINT/COMINT interception pod. Weapons aren’t part of their plan, but they did want an option to add them later, if necessary. The MvD intends to buy 4 Reapers for fielding on expeditionary operations by 2016, and achieve full operational capability from their base at Leeuwarden by 2017. The budget for this purchase is just EUR 100 – 250 million.

That budget could be a problem.

The brief to Parliament lists European airworthiness certification as a major budget risk. It is. The fact that Britain, France, and Italy will also be MQ-9 customers was an argument for a Dutch buy, because they create a pool of partners who can benefit from each other’s work. Cost pooling is an even bigger factor for eventual certification beyond restricted airspace, whose success will involve sense-and-avoid technologies, and certifications whose cost can’t be predicted. Past estimates have involved hundreds of millions of dollars.

The other source of significant risk to the program involves integration the wide-area ground scanning radar, and SIGINT/COMINT payloads. The scope of that effort will have to be assessed. It’s worth noting that payloads are subject to network effects: a larger customer list in Europe makes it easier or more attractive to add payloads, which then provide another reason for new customers to sign on. Sources: Dutch MvD, “Defensie kiest Reaper als onbemand vliegtuig” and “Kamerbrief voorstudie project MALE UAV”.

Nov 20/13: Euro MALE. Defence Ministers committed to the launch of 4 programs during the EU European Defence Agency’s Steering Board session, 1 of which centered around a 4-part program for UAVs. “Ministers tasked EDA to prepare the launch of a Category B project” to develop a Future European MALE platform, to be introduced from 2020 – 2025. Other documents, noting the obvious potential for ridicule since Future European MALE = FEMALE, refer to it as “MALE 2020” – a timeline that would be imperative for industrial and competitive reasons. EDA hasn’t launched the project yet. Once it does, can Europe’s traditionally fractious program negotiations and fragmented execution hit a 2020 target date?

In parallel, a coalition of countries also plan to create an operator community of UAV users, so they can share experiences and improve the foundation for future cooperation. Germany, France, Spain, Greece, Italy, the Netherlands and Poland have all joined.

Other areas of cooperation will include streamlining UAV certification in European airspace, now that its costs and uncertainties have already killed Germany’s major Eurohawk UAV program. In a related move, Austria, Belgium, Britain, the Czech Republic, Germany, France and Spain signed a joint investment program around technologies required for UAV use in civil airspace. Sources: EDA, “Defence Ministers Commit to Capability Programmes” | Les Echos, “Drones : des pays europeens s’engagent a collaborer”.

Nov 14/13: Germany. Chancellor Merkel’s narrow victory has an important military consequence. A draft version of the coalition agreement between Merkel’s center-right Christian Democrats and the center-left Social Democrats reportedly says that:

“We categorically reject illegal killings by drones. Germany will support the use of unmanned weapons systems for the purposes of international disarmament and arms control…. Before acquiring a qualitatively new arms system, we will thoroughly investigate all associated civil and constitutional guidelines and ethical questions.”

Translation: Don’t expect a purchase of Reaper or Heron UAVs during the lifetime of this 4-year legislative session. Sources: The Local.de, “Germany halts purchase of armed drones” | See also the left-wing <a href="http://truth-out.org/news/item/19904-how-europeans-are-o

Show more